Розробка DC-DC перетворювача для використання в системах активного балансування акумуляторних батарей  у форматі студентських змагань

Дмитро Ліпко; Олександр Федорович Бондаренко

doi:10.20535/2523-4455.mea.316127

Vol. 29 · Issue 3 · 2024 Dec 24, 2024 Electronic Systems and Signals

Development of a DC-DC Converter for Active Battery Balancing Systems in a Format of Student Competition

ДЛ

Дмитро Ліпко Corresponding Національний технічний університет України «Київський політехнічний інститут імені Ігоря Сікорського» Ukraine

ОБ

Олександр Федорович Бондаренко Національний технічний університет України «Київський політехнічний інститут імені Ігоря Сікорського» Ukraine

Pages316127.1-316127.8 PublishedDec 24, 2024

PDF (Ukrainian)

VOL 29 · ISS 3 · 2024 View issue

Abstract

The article presents the development of a DC-DC converter for active battery balancing systems in the format of student competition. Active balancing, which ensures stable energy transfer between battery cells, is critically important for optimizing their operation and extending their service life. Various topologies of DC-DC converters, in particular SEPIC, Push-Pull and DAB, are analyzed, their advantages and disadvantages are shown. The results of the work contribute to increasing the efficiency of battery balancing systems, extending their service life and developing students’ technical skills.

Keywords

#DC-DC converter #active balancer #storage battery #balancing system #power converter

References

A. Manzhelii, D. Lipko, and O. Bondarenko, “Comparative Analysis of DC-DC Converters for Micro-Mobility Vehicles,” in 2024 IEEE 7th International Conference on Smart Technologies in Power Engineering and Electronics (STEE), IEEE, Sep. 2024, p. TT1.45.1-TT1.45.5. doi: 10.1109/STEE63556.2024.10748120
D. Lipko, A. Manzhelii, I. Yamnenko, and O. Bondarenko, “Possibilities and Challenges of Partially Using a Charge-Discharge Cycle of Battery to Increase Its Resource,” in 2023 IEEE 4th KhPI Week on Advanced Technology, KhPI Week 2023 - Conference Proceedings, 2023. doi: 10.1109/KhPIWeek61412.2023.10312983
M. Evzelman, M. M. Ur Rehman, K. Hathaway, R. Zane, D. Costinett, and D. Maksimovic, “Active Balancing System for Electric Vehicles with Incorporated Low-Voltage Bus,” IEEE Trans Power Electron, vol. 31, no. 11, pp. 7887–7895, Nov. 2016, doi: 10.1109/TPEL.2015.2513432
G. Sugumaran and N. Amutha Prabha, “An Improved Bi-Switch Flyback Converter with Loss Analysis for Active Cell Balancing of the Lithium-Ion Battery String,” Journal of Electrical and Computer Engineering, vol. 2024, 2024, doi: 10.1155/2024/5556491
D. Lipko and O. F. Bondarenko, “Modified Active Balancer for Use in Multi-Module Batteries,” Technology and design in electronic equipment, №1-2, 2024, doi: 10.15222/TKEA2024.1-2.11
P. R. R. Somarowthu, S. K. Saxena, and D. B. Mahajan, “Isolated SEPIC Converter with a novel Voltage Clamp Circuit,” in 2018 IEEE International Conference on Power Electronics, Drives and Energy Systems (PEDES), IEEE, Dec. 2018, pp. 1–6. doi: 10.1109/PEDES.2018.8707789
M. V. Mosconi Ewerling, T. Brunelli Lazzarin, and C. H. Illa Font, “Proposal of an Isolated Two-Switch DC-DC SEPIC Converter,” in 2019 IEEE 15th Brazilian Power Electronics Conference and 5th IEEE Southern Power Electronics Conference (COBEP/SPEC), IEEE, Dec. 2019, pp. 1–6. doi: 10.1109/COBEP/SPEC44138.2019.9065718
J. Ahmad, C. H. Lin, M. S. Khan, H. D. Liu, and M. Fahad, “Modified Isolated SEPIC Converter for EV Charging and High Voltage Applications,” in 2023 International Conference on Power, Instrumentation, Energy and Control, PIECON 2023, Institute of Electrical and Electronics Engineers Inc., 2023. doi: 10.1109/PIECON56912.2023.10085847
N. Mohammad, M. Quamruzzaman, M. R. T. Hossain, and M. R. Alam, “Parasitic Effects on the Performance of DC-DC SEPIC in Photovoltaic Maximum Power Point Tracking Applications,” Smart Grid and Renewable Energy, vol. 04, no. 01, pp. 113–121, 2013, doi: 10.4236/sgre.2013.41014
M. S. Khan, C. H. Lin, J. Ahmad, M. Fahad, and H. D. Liu, “A Novel DC Electronic Load Topology Incorporated with Model Predictive Control Approach,” Mathematics, vol. 11, no. 15, Aug. 2023, doi: 10.3390/math11153353
M. Azizi, O. Husev, D. Vinnikov, and O. Veligorskyi, “Comparative Evaluation of Isolated dc-dc Converters for Low Power Applications,” in 2022 IEEE 20th International Power Electronics and Motion Control Conference (PEMC), IEEE, Sep. 2022, pp. 7–12. doi: 10.1109/PEMC51159.2022.9962944
S. Musumeci and S. Di Mauro, “Low voltage single fuel cell interface by Push-Pull converter: A case of study,” in 2017 6th International Conference on Clean Electrical Power (ICCEP), IEEE, Jun. 2017, pp. 541–548. doi: 10.1109/ICCEP.2017.8004741
H. Zhang and T. Isobe, “A Verification of Applying Superjunction MOSFETs in Dual-Active-Bridge Converters Operated with Minimal RMS Current,” IEEJ Journal of Industry Applications, p. 24004235, 2024, doi: 10.1541/ieejjia.24004235
R. Zgheib, I. Kamwa, and K. Al-Haddad, “Comparison between isolated and non-isolated DC/DC converters for bidirectional EV chargers,” in 2017 IEEE International Conference on Industrial Technology (ICIT), IEEE, Mar. 2017, pp. 515–520. doi: 10.1109/ICIT.2017.7913285
K. Bathala, D. Kishan, and N. Harischandrappa, “Soft Switched Current Fed Dual Active Bridge Isolated Bidirectional Series Resonant DC-DC Converter for Energy Storage Applications,” Energies (Basel), vol. 16, no. 1, Jan. 2023, doi: 10.3390/en16010258
F. Feng, J. Fang, U. Manandhar, H. B. Gooi, and P. Xie, “Impedance-Based Stability Analysis of DAB Converters With Single-, Double-, or Cooperative Triple-Phase-Shift Modulations and Input LC Filter,” Front Energy Res, vol. 10, Apr. 2022, doi: 10.3389/fenrg.2022.874477
B. Zhao, Q. Song, W. Liu, and Y. Sun, “Overview of dual-active-bridge isolated bidirectional DC-DC converter for high-frequency-link power-conversion system,” IEEE Trans Power Electron, vol. 29, no. 8, pp. 4091–4106, 2014, doi: 10.1109/TPEL.2013.2289913
Kang Xiangli, Shouxiang Li, and K. Smedley, “Analysis and modelling of a bidirectional push-pull converter with PWM plus phase-shift control,” in IECON 2016 - 42nd Annual Conference of the IEEE Industrial Electronics Society, IEEE, Oct. 2016, pp. 1268–1273. doi: 10.1109/IECON.2016.7793452
N. Hou and Y. W. Li, “Overview and Comparison of Modulation and Control Strategies for a Nonresonant Single-Phase Dual-Active-Bridge DC-DC Converter,” IEEE Trans Power Electron, vol. 35, no. 3, pp. 3148–3172, Mar. 2020, doi: 10.1109/TPEL.2019.2927930

Previous in issue Models of Acoustic Resonators in Studies of Sound-Absorbing Structures

§ 06 — Related

Similar Articles

Ivan Andriiovych Vakulenko, PhD, Assoc. Prof. Dmytro Anatoliiovych Mykolaiets, PhD, Assoc. Prof. Kateryna Serhiivna Klen, Simulation Modeling of a Filter-Compensating Converter for a Three-Phase Three-Wire Network , Microsystems, Electronics and Acoustics: Vol. 31 No. 2 (2026)
Myhailo Yuhymovych Artemenko, Larysa Mykolaivna Batrak, Serhii Yosyfovych Polishchuk, Apparent Power and Efficiency of Three-Phase Four-Wire System , Microsystems, Electronics and Acoustics: Vol. 23 No. 3 (2018)
Oleksandr Ivanovych Drozdenko, Oleksandr Hryhorovych Leiko, Radiation of maximum acoustic power by systems of hydroacoustic cylindrical piezoceramic transducers with circular polarization , Microsystems, Electronics and Acoustics: Vol. 23 No. 2 (2018)
Sergey M. Osinov, Viktor Fedorovich Zavorotnyi, Boris Ivanovych Lupyna, Olexandr Vasylovych Borisov, Modeling of Multifunctional Thermoresistive Transduser Used Heat Exchange Technology , Microsystems, Electronics and Acoustics: Vol. 24 No. 2 (2019)
Igor Yevheniiovych Korotyeyev, Marius Klytta, The Process Analysis in Domain of Two Variables , Microsystems, Electronics and Acoustics: Vol. 23 No. 2 (2018)
Viktor Fedorovich Zavorotnyi, Olexander Vasylovych Borisov, The laboratory tester of solar cells with dynamic reconfigutration of measuring system , Microsystems, Electronics and Acoustics: Vol. 23 No. 1 (2018)
Andrii Volodymyrovych Osinsky, Andrii Volodymyrovych Diahiliev, Oleksandr Vasylovych Borysov, Nataliia Mykolaivna Liakhova, Marat Serhiiovych Onachenko, Nina Olehivna Sukhovii, Ihor Vitaliiovych Masol, Volodymyr Ivanovych Osinsky, Record Efficiency of Solar Cells Based on Graded-Gap Trinitrides of Quantum Enestors-Zonistors , Microsystems, Electronics and Acoustics: Vol. 23 No. 5 (2018)
Maksim Oleksiiovych Korzhyk, Serhii Viktorovych Kurdiuk, Oleksii Volodymyrovych Korzhyk, Impedance Characteristics of a Plane-Parallel Acoustic Waveguide with Combined Borders at Two-Frequency Acoustical Exitation , Microsystems, Electronics and Acoustics: Vol. 23 No. 3 (2018)
Anton Vasylovych Kotsiubailo, Dr.Sc.(Eng.), Prof. Oleksandr Mykolaiovych Lysenko, WiFi-Based Control System for Active Lower Limb Orthosis: A Distributed Architecture Approach , Microsystems, Electronics and Acoustics: Vol. 31 No. 1 (2026)
Dr.Sc.(Eng.), Prof. Serhii Anatoliiovych Naida, Dr.Sc.(Eng.), Assoc. Prof. Oleksandr Ivanovych Drozdenko, PhD, Assoc. Prof. Pavlo Vasyliovych Popovych, канд. техн. наук, доц. Катерина Сергіївна Дрозденко, PhD Oleksandr Ihorovych Nyzhnyk, PhD Yaroslav Ivanovych Starovoit, Acoustic Localization of Aerial Objects and Practical Evaluation of its Accuracy , Microsystems, Electronics and Acoustics: Vol. 31 No. 1 (2026)

1-10 of 121 Next

You may also start an advanced similarity search for this article.

[1] A. Manzhelii, D. Lipko, and O. Bondarenko, “Comparative Analysis of DC-DC Converters for Micro-Mobility Vehicles,” in 2024 IEEE 7th International Conference on Smart Technologies in Power Engineering and Electronics (STEE), IEEE, Sep. 2024, p. TT1.45.1-TT1.45.5. doi: 10.1109/STEE63556.2024.10748120

[2] D. Lipko, A. Manzhelii, I. Yamnenko, and O. Bondarenko, “Possibilities and Challenges of Partially Using a Charge-Discharge Cycle of Battery to Increase Its Resource,” in 2023 IEEE 4th KhPI Week on Advanced Technology, KhPI Week 2023 - Conference Proceedings, 2023. doi: 10.1109/KhPIWeek61412.2023.10312983

[3] M. Evzelman, M. M. Ur Rehman, K. Hathaway, R. Zane, D. Costinett, and D. Maksimovic, “Active Balancing System for Electric Vehicles with Incorporated Low-Voltage Bus,” IEEE Trans Power Electron, vol. 31, no. 11, pp. 7887–7895, Nov. 2016, doi: 10.1109/TPEL.2015.2513432

[4] G. Sugumaran and N. Amutha Prabha, “An Improved Bi-Switch Flyback Converter with Loss Analysis for Active Cell Balancing of the Lithium-Ion Battery String,” Journal of Electrical and Computer Engineering, vol. 2024, 2024, doi: 10.1155/2024/5556491

[5] D. Lipko and O. F. Bondarenko, “Modified Active Balancer for Use in Multi-Module Batteries,” Technology and design in electronic equipment, №1-2, 2024, doi: 10.15222/TKEA2024.1-2.11

[6] P. R. R. Somarowthu, S. K. Saxena, and D. B. Mahajan, “Isolated SEPIC Converter with a novel Voltage Clamp Circuit,” in 2018 IEEE International Conference on Power Electronics, Drives and Energy Systems (PEDES), IEEE, Dec. 2018, pp. 1–6. doi: 10.1109/PEDES.2018.8707789

[7] M. V. Mosconi Ewerling, T. Brunelli Lazzarin, and C. H. Illa Font, “Proposal of an Isolated Two-Switch DC-DC SEPIC Converter,” in 2019 IEEE 15th Brazilian Power Electronics Conference and 5th IEEE Southern Power Electronics Conference (COBEP/SPEC), IEEE, Dec. 2019, pp. 1–6. doi: 10.1109/COBEP/SPEC44138.2019.9065718

[8] J. Ahmad, C. H. Lin, M. S. Khan, H. D. Liu, and M. Fahad, “Modified Isolated SEPIC Converter for EV Charging and High Voltage Applications,” in 2023 International Conference on Power, Instrumentation, Energy and Control, PIECON 2023, Institute of Electrical and Electronics Engineers Inc., 2023. doi: 10.1109/PIECON56912.2023.10085847

[9] N. Mohammad, M. Quamruzzaman, M. R. T. Hossain, and M. R. Alam, “Parasitic Effects on the Performance of DC-DC SEPIC in Photovoltaic Maximum Power Point Tracking Applications,” Smart Grid and Renewable Energy, vol. 04, no. 01, pp. 113–121, 2013, doi: 10.4236/sgre.2013.41014

[10] M. S. Khan, C. H. Lin, J. Ahmad, M. Fahad, and H. D. Liu, “A Novel DC Electronic Load Topology Incorporated with Model Predictive Control Approach,” Mathematics, vol. 11, no. 15, Aug. 2023, doi: 10.3390/math11153353

[11] M. Azizi, O. Husev, D. Vinnikov, and O. Veligorskyi, “Comparative Evaluation of Isolated dc-dc Converters for Low Power Applications,” in 2022 IEEE 20th International Power Electronics and Motion Control Conference (PEMC), IEEE, Sep. 2022, pp. 7–12. doi: 10.1109/PEMC51159.2022.9962944

[12] S. Musumeci and S. Di Mauro, “Low voltage single fuel cell interface by Push-Pull converter: A case of study,” in 2017 6th International Conference on Clean Electrical Power (ICCEP), IEEE, Jun. 2017, pp. 541–548. doi: 10.1109/ICCEP.2017.8004741

[13] H. Zhang and T. Isobe, “A Verification of Applying Superjunction MOSFETs in Dual-Active-Bridge Converters Operated with Minimal RMS Current,” IEEJ Journal of Industry Applications, p. 24004235, 2024, doi: 10.1541/ieejjia.24004235

[14] R. Zgheib, I. Kamwa, and K. Al-Haddad, “Comparison between isolated and non-isolated DC/DC converters for bidirectional EV chargers,” in 2017 IEEE International Conference on Industrial Technology (ICIT), IEEE, Mar. 2017, pp. 515–520. doi: 10.1109/ICIT.2017.7913285

[15] K. Bathala, D. Kishan, and N. Harischandrappa, “Soft Switched Current Fed Dual Active Bridge Isolated Bidirectional Series Resonant DC-DC Converter for Energy Storage Applications,” Energies (Basel), vol. 16, no. 1, Jan. 2023, doi: 10.3390/en16010258

[16] F. Feng, J. Fang, U. Manandhar, H. B. Gooi, and P. Xie, “Impedance-Based Stability Analysis of DAB Converters With Single-, Double-, or Cooperative Triple-Phase-Shift Modulations and Input LC Filter,” Front Energy Res, vol. 10, Apr. 2022, doi: 10.3389/fenrg.2022.874477

[17] B. Zhao, Q. Song, W. Liu, and Y. Sun, “Overview of dual-active-bridge isolated bidirectional DC-DC converter for high-frequency-link power-conversion system,” IEEE Trans Power Electron, vol. 29, no. 8, pp. 4091–4106, 2014, doi: 10.1109/TPEL.2013.2289913

[18] Kang Xiangli, Shouxiang Li, and K. Smedley, “Analysis and modelling of a bidirectional push-pull converter with PWM plus phase-shift control,” in IECON 2016 - 42nd Annual Conference of the IEEE Industrial Electronics Society, IEEE, Oct. 2016, pp. 1268–1273. doi: 10.1109/IECON.2016.7793452

[19] N. Hou and Y. W. Li, “Overview and Comparison of Modulation and Control Strategies for a Nonresonant Single-Phase Dual-Active-Bridge DC-DC Converter,” IEEE Trans Power Electron, vol. 35, no. 3, pp. 3148–3172, Mar. 2020, doi: 10.1109/TPEL.2019.2927930

Development of a DC-DC Converter for Active Battery Balancing Systems in a Format of Student Competition

Abstract

Keywords

References

Similar articles in this journal

Quasistatic Identification of The Shading Structure of Solar Panels by The Method of Cardinal Number Vectors

A A Complex Method for Non-invasive Fetal Electrocardiogram Signal Extraction and Cardiac Arrhythmia Classification

Simulation Modeling of a Filter-Compensating Converter for a Three-Phase Three-Wire Network

Similar Articles