КРИСТАЛІЗАЦІЯ РОЗЧИНУ NaCl У ВАКУУМНОМУ ВІДЦЕНТРОВОМУ ПЛІВКОВОМУ ДИСТИЛЯТОРІ

Petro O. Barabash; Andrii S. Solomakha; Volodymyr G. Rifert; Valerii G. Petrenko; Volodymyr I. Usenko; Vladyslav P. Boianivskyi

doi:10.20535/kpi-sn.2019.4.181280

Vol. · Issue 4 · 2019 Oct 22, 2019 article

CRYSTALLIZATION OF A NaCl SOLUTION IN A VACUUM CENTRIFUGAL FILM DISTILLER

Petro O. Barabash Corresponding Igor Sikorsky Kyiv Polytechnic Institute, Ukraine Ukraine

Andrii S. Solomakha Igor Sikorsky Kyiv Polytechnic Institute, Ukraine Ukraine

Volodymyr G. Rifert Igor Sikorsky Kyiv Polytechnic Institute, Ukraine Ukraine

Valerii G. Petrenko Igor Sikorsky Kyiv Polytechnic Institute, Ukraine Ukraine

Volodymyr I. Usenko Igor Sikorsky Kyiv Polytechnic Institute, Ukraine Ukraine

Vladyslav P. Boianivskyi Igor Sikorsky Kyiv Polytechnic Institute, Ukraine Ukraine

PublishedOct 22, 2019

PDF (Ukrainian)

KPISN 4 VOL · 4

VOL · ISS 4 · 2019 View issue

Abstract

Background. The use of centrifugal forces in heat exchangers provides high efficiency of heat and mass transfer processes and allows creating devices that are operable under microgravity conditions. The short contact time of the solution with the heat exchange surface prevents deposits of dissolved substances when concentration of the solution increases. As a result, the centrifugal distillation apparatus can operate as a crystallizer, which provides an increase in the coefficient of water recovery in the life support systems for deep space missions. Objective. The purpose of the paper is investigation of a single-stage centrifugal flash-boiling distiller for concentration of a NaCl solution. Methods. Experimental studies on a prototype of centrifugal vacuum single-stage distiller. Results. The results were obtained by concentrating a NaCl solution and in the crystallization mode (when precipitation of dissolved NaCl crystals begins). The physicochemical temperature depression was determined depending on the concentration of the solution and the pressure in the apparatus with quality control of the obtained distillate. The results were compared with the data of other authors, and the match was pretty good. Using a filter in a hot circuit allows you to work in crystallizer mode without the appearance of deposits on the structural elements of the apparatus. Conclusions. Intensive heat transfer in a centrifugal apparatus ensures the complete operation of the solution overheating, which makes it possible to use it to study the physicochemical temperature depression of solutions at different pressures. In this case, the quality of the distillate does not depend on the concentration of dissolved substances in the hot circuit (and in the crystallization mode). The use of the filter in the hot circuit allows the system to operate in crystallizer mode until the filter becomes clogged. After replacing the filter, the process can be extended.

Keywords

#Crystallization #Centrifugal distiller #Microgravity #NaCl

References

B. Morgan et al. , “A discussion of integrated life support and in situ resource utilization architectures for mars surface missions”, in Proc. 48th Int. Conf. Environmental Systems Albuquerque , New Mexico, ICES-2018-23, 8–12 July 2018.
L. Kelsey and B. Finger, “Inspiration Mars ETDU water management system test results”, in Proc. 44th Int. Conf. Environmental Systems , Arizona, ICES-2014-270, 13–17 July 2014.
V. Patel et al. , “Cascade Distillation System – A water recovery system for deep space missions”, in Proc. 44th Int. Conf. Environmental Systems , Arizona , ICES-2014-12, 13–17 July 2014.
V.G. Rifert et al. , “Improvement of the distillation methods by using centrifugal forces for water recovery in space flight application”, in Proc. 46th Int. Conf. Environmental Systems , Vienna, ICES-2016-369, 10–14 July 2016.
V.G. Rifert et al. , “Improvement the cascade distillation system for long-term space flights”, in Proc. 68th International Astronautical Congress , Adelaide, Australia, IAC-17-A1.IP.25, 25–29 September 2017.
V. Rifert et al. , “Cascaded Distillation Technology for Water Processing in Space”, SAE Technical Paper, 2003-01-2625, 2003. doi: 10.4271/2003-01-2625
O.A. Dolinskij et al. , “Temperature field of an overheated film of a fluid moving along a rotating disk”, Industrial Heat Eng. , vol. 5, no. 5, pp. 33–38, 1983.
O.A. Dolinskij et al. , “Calculation of the concentration of salts on the surface of an adiabatically evaporating solution film”, Industrial Heat Eng. , vol. 5, no. 6, pp. 16–21, 1983.
O.A. Dolinskij, “The results of an experimental study of the adiabatic evaporation of a liquid film on a rotating disk”, Industrial Heat Eng. , vol. 10, no. 4, pp. 41–45, 1988.
B.P. Nikol'skij, Chemist's Handbook , 2 ed. Moscow, SU: Himiya, 1986.
I.I. Chernobyl'skij, Machines and Apparatus for Chemical Production , 3 ed. Moscow, SU: Mashinostroenie, 1974.

Previous in issue MEASUREMENT OF ULTRASONIC POWER OF ULTRASONIC THERAPY DEVICES Next in issue INVESTIGATION OF THE CATALYTIC EFFECT OF POTASSIUM TRET-BUTOXIDE IN THE AMIDATION REACTIONS OF RAPESEED OIL ACYLGLYCERIDES

§ 06 — Related

[1] B. Morgan et al. , “A discussion of integrated life support and in situ resource utilization architectures for mars surface missions”, in Proc. 48th Int. Conf. Environmental Systems Albuquerque , New Mexico, ICES-2018-23, 8–12 July 2018.

[2] L. Kelsey and B. Finger, “Inspiration Mars ETDU water management system test results”, in Proc. 44th Int. Conf. Environmental Systems , Arizona, ICES-2014-270, 13–17 July 2014.

[3] V. Patel et al. , “Cascade Distillation System – A water recovery system for deep space missions”, in Proc. 44th Int. Conf. Environmental Systems , Arizona , ICES-2014-12, 13–17 July 2014.

[4] V.G. Rifert et al. , “Improvement of the distillation methods by using centrifugal forces for water recovery in space flight application”, in Proc. 46th Int. Conf. Environmental Systems , Vienna, ICES-2016-369, 10–14 July 2016.

[5] V.G. Rifert et al. , “Improvement the cascade distillation system for long-term space flights”, in Proc. 68th International Astronautical Congress , Adelaide, Australia, IAC-17-A1.IP.25, 25–29 September 2017.

[6] V. Rifert et al. , “Cascaded Distillation Technology for Water Processing in Space”, SAE Technical Paper, 2003-01-2625, 2003. doi: 10.4271/2003-01-2625

[7] O.A. Dolinskij et al. , “Temperature field of an overheated film of a fluid moving along a rotating disk”, Industrial Heat Eng. , vol. 5, no. 5, pp. 33–38, 1983.

[8] O.A. Dolinskij et al. , “Calculation of the concentration of salts on the surface of an adiabatically evaporating solution film”, Industrial Heat Eng. , vol. 5, no. 6, pp. 16–21, 1983.

[9] O.A. Dolinskij, “The results of an experimental study of the adiabatic evaporation of a liquid film on a rotating disk”, Industrial Heat Eng. , vol. 10, no. 4, pp. 41–45, 1988.

[10] B.P. Nikol'skij, Chemist's Handbook , 2 ed. Moscow, SU: Himiya, 1986.

[11] I.I. Chernobyl'skij, Machines and Apparatus for Chemical Production , 3 ed. Moscow, SU: Mashinostroenie, 1974.

CRYSTALLIZATION OF A NaCl SOLUTION IN A VACUUM CENTRIFUGAL FILM DISTILLER

Abstract

Keywords

References

Similar articles in this journal

TWO-STAGE SEGMENTATION PIPELINE FOR SATELLITE PARKING LOT PAVED AREA ESTIMATION

A SPARSE ANP FORMALIZATION WITH DATA-DRIVEN BINARY COMPARISONS AMONG HOMOGENEOUS COMPONENTS FOR RESOURCE ALLOCATION PRIORITIZATION

DEVELOPMENT OF A METHOD FOR FORMALIZING DYNAMIC THERMAL PORTRAITS FOR ROBUST TARGET DETECTION

Most read articles by the same author(s)